Attachment with suture via bone tunnels is comparable biomechanically to single row anchor suture for reattachment of Achilles tendon to bone

N. Aizah, A. Haseeb, M.R. Draman

¹Universiti Malaya Medical Centre, Orthopaedic Surgery (NOCERAL), Kuala Lumpur, Malaysia

²Faculty of Medicine, Universiti Malaya, Orthopaedic Surgery (NOCERAL), Kuala Lumpur, Malaysia

Winner of the BOFAS 2024 First Trainee Prize & Klenerman Prize for Basic Science Paper (Podium)

Insertional Achilles tendinitis with considerable degeneration that failed non-operative treatment typically requires tendon debridement and reattachment to bone. It is common practice for tendons to be reattached back with anchor sutures, but this poses a challenge to patients who are not able to afford them. Bony anchorage of tendons may be performed by passing sutures through tunnels, but the strength of repair compared to by using anchors is not known. We investigated the load at clinical and catastrophic failure of these two methods of reattachment. Sixteen paired Achilles tendons along with the calcaneus were harvested from eight fresh frozen cadavers.

Paired randomization was done. For the anchor suture group, two 5’0 anchors with polyethylene #2 sutures were used for reattachment whereas for the suture only group, tendons were reattached to bone using braided polyester #2 sutures via two bony tunnels. All samples were mounted on a materials testing system and preloaded at 50N for 60sec before load to failure at a rate of 1mm/sec. With the assumption that preloading has removed tendon crimp and any subsequent extension is a result of gapping at the repair site, loads at 5mm, 10mm, 15mm, and 20mm of extension were noted as well as the maximal load at failure. We found higher loads were needed to cause an extension of 5 to 20mm in the suture only group compared to the anchor suture group but these data were not significant. On the other hand, the anchor suture group required higher loads before catastrophic failure occurred compared to the suture only group, but this again is not significant.

We conclude that suture only reattachment of the Achilles tendon is comparable in strength with anchor suture reattachment, and this method of reattachment can be considered for patients who do not have access to anchor sutures.

Click thumbnail below to view poster / thumbnail: